Bike Insurance Claim for Tyre Burst: Tyre Protect Guide 2026
What Is a Tyre Burst Claim
A tyre burst claim covers the cost of repairing or replacing your two-wheeler after the event described. It falls under the own-damage section of a comprehensive bike policy, not third-party.
Standard own-damage cover excludes tyre damage unless the tyre fails as a direct result of an accident. Tyre Protect pays for the tyre even when the burst is the cause of the fall. Consumables cover adds tyre, brake pads, and engine oil to the standard payout.
Trigger Events
- Sidewall burst on highway - High-speed burst at 60 km per hour and above.
- Pothole hit - Sharp pothole edge cuts the tyre wall.
- Slow puncture leading to skid - Air loss while riding and rider lost balance.
- Tube blowout on tube-type tyres - Cheaper bikes with tube tyres face inner tube failure.
Why Tyre Burst Matters in India
Two-wheelers account for over 70% of all motor accidents in India. Two-wheeler tyre burst risk goes up sharply during monsoon, festive traffic, and peak office hours. A two-wheeler hit-and-run, theft, or engine seizure can cost Rs 8,000 to Rs 1.2 lakh out of pocket if you do not have the right cover.
The Motor Vehicles Act 1988 makes third-party bike insurance mandatory. Section 146 sets a Rs 2,000 fine plus 3 months penalty under MV Act for riding uninsured. But third-party alone does not cover your own bike damage, theft, or engine failure. That is where tyre burst cover matters.
Pay Rs 1,400 to Rs 4,500 a year for comprehensive cover. You get up to Rs 1.5 lakh of own-damage protection, third-party liability up to Rs 7.5 lakh, and personal accident cover up to Rs 15 lakh under Section 147.
What the Cover Pays Out
Comprehensive bike insurance pays for tyre burst subject to depreciation rules and policy limits. With Zero Depreciation as an add-on, the provider pays 100% of part-replacement cost without depreciation cut. Without it, plastic and rubber parts depreciate 50% in year one.
Included in This Claim
- Damaged bike parts, paint, and labour
- Bike towing to network garage up to 50 km
- Spare parts at IDV depreciation slab
- Personal accident cover for owner-rider up to Rs 15 lakh under Section 147
Standard Exclusions
- Tyre damage from wear and tear without an accident trigger
- Tyre damage from unauthorised modification, like an oversized rim
- Tyre damage during racing or off-road use
- Damage older than 24 hours and not reported promptly
Pair this cover with Tyre Protect or Consumables Cover for the tyre burst scenario. It moves your out-of-pocket cost from Rs 5,000 to under Rs 500 in most cases.
Typical Claim Payouts and Premium Bands
Two-wheeler premiums depend on cc, age, RTO zone, IDV, and add-on choices. Below are typical 1-year premium ranges as of 2026:
| Bike Type | Third-Party | Comprehensive | With Add-Ons |
|---|---|---|---|
| 100 to 125cc commuter | Rs 752 | Rs 1,400 to Rs 2,400 | Rs 2,100 to Rs 3,800 |
| 150 to 200cc geared | Rs 1,193 | Rs 2,200 to Rs 3,900 | Rs 3,200 to Rs 5,600 |
| 250 to 400cc performance | Rs 1,366 | Rs 3,200 to Rs 5,800 | Rs 4,800 to Rs 8,200 |
| 500cc plus and superbike | Rs 2,804 | Rs 5,800 to Rs 12,500 | Rs 8,500 to Rs 17,800 |
Actual premium depends on your bike, RTO, and add-on stack. Get an exact quote at hizuno.com/bike-insurance.
Step-by-Step: File a Tyre Burst Claim
Following this exact sequence keeps your claim cashless and stops out-of-pocket spend at the garage gate.
- Call Zuno claim helpline within 24 hours - Report the event from the spot. Note the claim reference number sent over SMS.
- Take time-stamped photos of damage - Capture all four angles, the bike number plate, the road, and any nearby objects involved.
- File the FIR or get the police memo - FIR is not mandatory unless a third party is injured. Police memo suffices.
- Move the bike to a network garage - Choose any of the 5,000+ network garages for cashless repair. Roadside Assistance covers towing up to 50 km.
- Submit the claim form and documents - Upload the claim form, FIR copy, RC, DL, and policy document via the app or the helpline.
- Survey and settlement - Surveyor inspects within 48 hours. network garages release the bike after Zuno settles. Typical timeline: 7 to 14 working days.
Documents You Need at the Network Garage
- Photos of the burst tyre and skid mark on the road
- Police memo or panchnama if a third party was involved
- Bike RC, policy, driving licence
- Network Garage invoice for new tyre and labour
City and State Nuances for Bike Insurance
Two-wheeler premiums vary sharply by city. Higher theft zones, monsoon-flood cities, and dense-traffic metros push base premium up. Use the table to plan your add-on stack:
| City | Premium Adjustment | Recommended Add-On |
|---|---|---|
| Mumbai | +12% (monsoon + theft zone) | Engine Protect, RSA |
| Delhi NCR | +8% (high traffic, theft) | Roadside Assistance, Helmet Cover |
| Bangalore | +6% (traffic + tech-hub theft) | RSA, Consumables |
| Chennai | +10% (cyclone + monsoon) | Engine Protect, Consumables |
| Hyderabad | +4% (best metro RTO) | Zero Dep, RSA |
| Pune | +5% (Maharashtra base) | Zero Dep, Engine Protect |
| Kolkata | +9% (flood + tram density) | Engine Protect, RSA |
| Ahmedabad | +3% (low loss ratio) | Zero Dep, NCB Protect |
| Jaipur | +2% (desert dust) | Consumables, Engine Protect |
| Kochi | +11% (highest monsoon load) | Engine Protect mandatory |
Mumbai, Chennai, Kochi, and Kolkata are the four cities where Engine Protect pays back in the first monsoon. Bangalore and Delhi NCR riders should pick Roadside Assistance for traffic-zone breakdowns. Pune and Hyderabad RTOs offer the lowest two-wheeler base premiums in India.
Common Mistakes Indian Bike Owners Make
Letting your bike policy lapse by even a single day. You lose the entire No Claim Bonus (up to 50%) and the bike must clear a fresh inspection before the new policy starts.
- Skipping engine protect in monsoon cities - Mumbai, Chennai, Kochi, Kolkata bikes lose engine warranty cover the moment water enters the air intake. Add this for under Rs 500 a year.
- Picking lowest IDV to cut premium - Underinsuring your bike saves Rs 200 to Rs 400 today but cuts your theft and total-loss claim payout sharply.
- Forgetting to declare add-on parts - Aftermarket exhaust, top-box, or accessories are excluded unless declared at policy start.
- Renewing one day after expiry - Even a 1-day lapse forfeits the No Claim Bonus and triggers fresh inspection at the network garage.
- Choosing third-party only for a new bike - Third-Party covers nothing on your own bike. A pothole fall or theft becomes an out-of-pocket cost.
Pro Tips to Save on Bike Insurance
- Bundle Engine Protect and Zero Depreciation for under Rs 1,200 - These two add-ons together pay back the moment you face a single monsoon claim.
- Renew 30 days before expiry - Carrying over NCB without lapse is the cheapest way to stay protected and keep the discount.
- Compare third-party and comprehensive premium online - Comprehensive costs only Rs 800 to Rs 2,000 more than third-party for most commuter bikes and covers your own damage.
- Pick a higher voluntary deductible - Choosing Rs 1,500 instead of Rs 500 voluntary deductible cuts premium by 8% to 12%.
- Install an anti-theft device certified by ARAI - Approved anti-theft devices unlock a 2.5% own-damage discount on most bikes.
Frequently Asked Questions
Related Bike Insurance Guides
- Bike Insurance Renewal Online
- Comprehensive Bike Insurance
- Third-Party Bike Insurance
- Zero Depreciation Add-On for Bikes
- Bike Insurance NCB Guide
- Bike RTO Transfer Guide
Sources: Content based on information published by IRDAI, ARAI, MoRTH, Parivahan Sewa, General Insurance Council (GIC), and other relevant regulatory or industry sources, as applicable.
Disclaimer: Premiums and amounts shown are indicative and approximate reference figures only; the actual figure varies with the vehicle's age, No Claim Bonus, geography (RTO zone) and various other parameters. The company offers products under Motor, Health, and Commercial Insurance. For risk factors, terms and conditions, exclusions, and product features, please read the policy wording, sales brochure, and prospectus carefully before concluding a sale. Zuno General Insurance Limited | IRDAI Reg. No. 159 | CIN: U66000MH2016PLC273758 | Registered Office: 2nd Floor, Tower 3, Wing B, Kohinoor City Mall, Kohinoor City, Kirol Road, Kurla (West), Mumbai 400070 | Toll-Free: 1800 12000 | Landline: 022 42312000 (Call charges applicable) | Website: www.hizuno.com | Email: support@hizuno.com.
Section 41 of the Insurance Act, 1938: No person shall allow or offer to allow, directly or indirectly, as an inducement to any person to take out, renew, or continue an insurance policy in respect of any kind of risk relating to lives or property in India, any rebate of the whole or part of the commission payable or any rebate of the premium shown on the policy, nor shall any person taking out, renewing, or continuing a policy accept any such rebate.